歡迎光臨山汽集團網站!

400-879-1999

點擊撥打服務熱線:400-879-1999
您現在所在的位置: 首頁> 新聞資訊 > 行業動態 >
站內搜索
關于山汽

聯系人:劉老師

電話:400-879-1999

公司:山東山汽工程機械(集團)有限公司

地址:山東省萊州市206國道與308省道交叉口東南50米

自動攪拌車駕駛時有何注意事項。

所屬分類: 行業動態 發布時間:2020-07-08 來源:http://m.dbspider.com/ 瀏覽量:18

駕駛全自動攪拌車的司機們一定要看這一篇文章,這篇文章給你說說在駕駛時有何注意事項。
Drivers who drive full-automatic mixer must read this article. This article will tell you what to pay attention to when driving.
1、液壓系統壓力應符合使用說明書中的規定,不得隨意調整。液壓油的油質和油量應符合原定要求。
1. The pressure of the hydraulic system should be in accordance with the provisions of the operation manual, and should not be adjusted at will. The quality and quantity of hydraulic oil should meet the original requirements.
2、工作時,不得將手伸入旋轉的攪拌筒內,嚴禁將手伸入主卸料溜槽和加長卸料溜槽的連接部位,以免發生事故。
2. When working, do not put your hand into the rotating mixing drum, do not put your hand into the connection between the main discharge chute and the extended discharge chute, so as to avoid accidents.
3、環境溫度高于+25攝氏度,從裝料、運輸、到卸料延續時間不得超過60分鐘,環境溫度低于+25攝氏度,上述時間不得超過90分鐘。
3. If the ambient temperature is higher than + 25 ℃, the duration from loading, transportation to unloading shall not exceed 60 minutes; if the ambient temperature is lower than + 25 ℃, the above time shall not exceed 90 minutes.
4、冬期施工時,應切實做到:開機前檢查是否結冰;下班時認真排除拌筒內及供水系統內殘存積水,關閉水泵開關,將控制手柄置于“停止”位置。5、在施工現場卸料完畢后,應立即用攪拌車隨帶的軟管沖洗進料斗、出料斗、卸料溜槽等處,清除粘附在車身各處的污泥及混凝土。在返回攪拌站的途中,應向攪拌筒內注150---200L水以清洗筒壁及葉片粘結的混凝土殘渣。
4. During winter construction, it is necessary to check whether there is icing before starting the machine; when off duty, carefully remove the residual water in the mixing drum and water supply system, turn off the water pump switch, and put the control handle at the "stop" position. 5. After unloading at the construction site, the inlet hopper, discharge hopper and discharge chute should be flushed with the hose attached to the mixer to remove the sludge and concrete adhering to the vehicle body. On the way back to the mixing station, 150-200l water should be injected into the mixing drum to clean the concrete residue bonded by the cylinder wall and blades.
6、攪拌車裝料前,應先排凈拌筒內殘存的積水和雜物。在運輸過程中要不停的轉動,以防混凝土離析。攪拌車到達工地和卸料之前,應先使拌筒全速以14—18轉/分轉動1—2分鐘,然后再進行反轉卸料。反轉之前,應使攪拌筒停穩不轉。
6. Before the mixing truck is loaded, the residual water and sundries in the mixing drum shall be drained. In the process of transportation, keep rotating to prevent concrete segregation. Before the mixer truck arrives at the construction site and unloads, the mixing drum shall be rotated at full speed at 14-18 rpm for 1-2 minutes, and then reverse unloading shall be carried out. Before reversing, the mixing drum should be stopped stably.
7、每天工作結束后,司機應負責向攪拌筒內注入清水并高速(14—18轉/分)旋轉5—10分鐘,然后將水排去,以保證筒內清潔。用高壓水清洗攪拌筒各個部分時,應注意避開儀表及操縱桿等部位。壓力水噴嘴與車身油漆表面間的距離不得小于40厘米。
7. At the end of each day's work, the driver should inject fresh water into the mixing drum and rotate it at high speed (14-18 RPM) for 5-10 minutes, and then drain the water to ensure the cleanness of the drum. When cleaning each part of the mixing drum with high pressure water, pay attention to avoid the instrument and control rod. The distance between the pressure water nozzle and the paint surface of the vehicle body shall not be less than 40 cm.
8、清除攪拌筒內外積污及殘存的混凝土渣塊時,以及在機修人員進入筒內進行檢修和焊補作業時,需先關閉汽車發動機,使攪拌筒完全停止轉動。在機修人員進入筒內工作期間,須保證拌筒內通風良好,空氣新鮮,無可然氣體及有害灰塵,氧氣供應充足。在筒內使用電動工具操作時,操作人員要有良好的絕緣保護。
8. When removing the dirt inside and outside the mixing drum and the remaining concrete slag, and when the machine maintenance personnel enter the cylinder for maintenance and welding repair, it is necessary to turn off the automobile engine to stop the mixing drum completely. During the period when the machine maintenance personnel enter the cylinder, they must ensure that the mixing drum is well ventilated, the air is fresh, there is no natural gas and harmful dust, and the oxygen supply is sufficient. When using electric tools in the cylinder, the operator should have good insulation protection.
熱門產品 / HOT PRODUCT
4噸B正側
推薦產品

4噸B正側

5.5方平口攪拌車
推薦產品

5.5方平口攪拌車

1.8方多功能攪拌車
推薦產品

1.8方多功能攪拌車

3.5噸B款正側
推薦產品

3.5噸B款正側

3.5方A款自動攪拌一體機
推薦產品

3.5方A款自動攪拌一體機

4.0方自動攪拌一體機
推薦產品

4.0方自動攪拌一體機

2.6方自動攪拌一體車
推薦產品

2.6方自動攪拌一體車

3.5方A款自動系列
推薦產品

3.5方A款自動系列

4噸A斜前
推薦產品

4噸A斜前

3.5噸A斜前
推薦產品

3.5噸A斜前

3.5方D款自動攪拌一體機
推薦產品

3.5方D款自動攪拌一體機

3.5方C款攪拌一體車
推薦產品

3.5方C款攪拌一體車

3.5方D款攪拌車
推薦產品

3.5方D款攪拌車

4噸C斜前
推薦產品

4噸C斜前

5.5方自動攪拌一體機
推薦產品

5.5方自動攪拌一體機

0.5方攪拌車
推薦產品

0.5方攪拌車

1.6方平口攪拌車
推薦產品

1.6方平口攪拌車

4方同步旋轉攪拌車
推薦產品

4方同步旋轉攪拌車

3.5方C款自動攪拌一體機
推薦產品

3.5方C款自動攪拌一體機

3.5噸C正側
推薦產品

3.5噸C正側

首頁 產品 電話 置頂
99视频精品全部在线观看,99久在线国内在线播放免费观看,99精品热视频这里只有精品